Zarvan
ELITE MEMBER
- Joined
- Apr 28, 2011
- Messages
- 54,470
- Reaction score
- 87
- Country
- Location
- Other squadrons reported frequent unserviceability of mobile surface-to-air Akash Missile system and long duration downtime, which means that the missiles are dysfunctional and may not be cocked and loaded against enemy in contingency
- Several government agencies, including missile manufacturer Bharat Dynamics Limited, Bharat Electronics Limited, did not tell the truth to the government about malfunctioning Akash Missile system and poor quality of spare parts provided by the private vendors
- CAG was perhaps far-sighted, when in a 2017 report, the national auditor observed that Akash Missiles cannot be trusted in situation of a war
On 3 June, 2018, Akash Missile's Transportation and Loading Vehicle (TLV), parked at an Air Force Squadron, was jolted after a sudden burst of tube followed by shearing off wheel bolts due to impact. The incident shocked Air Force headquarters. The Air Force officials wanted not only wanted the routine analysis of the incident, but also an in-depth discussion with Defence Research and Development Laboratory (DRDL), a multi-disciplinary Missile System laboratory under the Defence Research and Development Organisation (DRDO) to unearth issues hampering the functioning of the strategic weapon system.
More than a month later, another squadron reported cracks on air intake caps of dummy missiles. An investigation by Firstpost revealed that the incidents were followed by other squadrons reporting frequent unserviceability of mobile surface-to-air Akash Missile system and long duration downtime, which means that the missiles are dysfunctional and may not be cocked and loaded against enemy in contingency. This incident forced Guided Weapon Maintenance Department of Air Force on 5 September 2018 to raise the issue, where they clearly stated that the "Squadrons have been reporting frequent unserviceability of Missiles and it has been noticed that time taken to resolve these failures is considerably high due to delay in analysis of failures."
The sheer inertia of government defence enterprise involved in Akash Missile production and maintenance reached to such an alarming level that at least three squadrons of Akash in February 2019 reported that missile system remained down or simply broken and sometimes even out of order during 90 percent of the time since their date of commissioning. These squadrons were commissioned between 2013-2015 to counter Chinese aggression.
Multiple government agencies, including Missile manufacturer Bharat Dynamics Limited (BDL) which comes under the Ministry of Defence, Bharat Electronics Limited (BEL) which is responsible for radars and maintenance and the DRDO, did not tell the truth to the government about malfunctioning Akash Missile system and poor quality of spare parts provided by the private vendors.
The malfunction of Integrated Air Compressor and Storage Facility (IACSF) revealed another shocker and the Air Force mentioned it on record that the IACSFs of Akash Missile System units are unserviceable due to wobbling and vibration, pneumatic leakage, breaking of mounting pads and bolts. A missile had failed to take off during combined guided weapon firing exercise known as 'CROSSBOW-18' and a team of Missile System Quality Assurance Agency (MSQAA), BDL and DRDL was constituted to investigate the failure.
If there is an emergent situation, several Akash sqaudron may not be able to launch counter offensive because deficiencies in many of the system including hydraulic oil leakage and container pressure leakage, which is pending since 2017. Getty Images
MSQAA is an independent inspection Agency under the administrative and functional control of Director General Aeronautical Quality Assurance, which comes under the Department of Defence Production of Defence Ministry. The incidents of leakage from fuel tanks and leakage in pressurised Missile containers were taken so lightly that the Air Force, responsible to secure the nation from aerial threats, was forced to direct to the DRDL, BEL and BDL that present configuration of certain systems of Akash Missile will not be acceptable for future squadrons, which are under the process of procurement. The Air Force, BDL, BEL and DRDL are yet to respond to a questionnaire sent by Firstpost on 24 November.
Details expose criminal act by government defence enterprises
If there is an emergent situation, several Akash sqaudron may not be able to launch counter offensive because deficiencies in many of the system including hydraulic oil leakage and container pressure leakage, which is pending since 2017. The complaints received from Air Force headquarters, Eastern Air Command and other Akash field units reveals there is no back-to-back agreement with vendors for equipment under warranty, making it difficult to repair the faults. Documents reviewed by Firstpost showed that almost all squadrons have expressed that they are unable to get proper feedback from BEL on repairing the faults in Missile System and on problems plaguing Akash Missiles which Indian agencies are ill-equipped to resolve. Surprisingly the field engineers, who are supposed to rectify the critical snags, are not even aware of any action plan.
Documents further said: "Currently majority of the Akash field engineers are working to pass information about issues without any tangible technical output. The untrained and poorly equipped field engineers are neither aware of any corrective action plan nor they are committed."
The documents also pointed to massive delay in supply of spares for Missile System, virtually grounding them for for six months to a year. Air Force in a meeting had informed that most of the problems reported in 2017 were pending for over a year now. The documents also pointed at the repairing of Akash trailers which are covered under annual maintenance contract. It said: "Akash Trailers serviceability is poor and some cases spares supplied to Akash Missile units are not configured as per system requirement which is affecting equipment serviceability in case of failure."
Bharat Dynamics Limited (BDL) the manufacturer of Akash Missile has not been able to resolve three important issues for the last two to three years. BDL, founded in 1970, is a government enterprise under the administrative control of the Ministry of Defence. It is learnt that BDL was told in high level meeting convened last year to come out with solid plan after conducting an investigation and study of faults in Akash Missile System within a month on long delays of critical faults. Even the investigation to unearth and address the issues was delayed.
Some spares for Akash Missiles are not fit and functional and this is affecting the equipment serviceability in case of failure. Getty Images
The Air Force has refused to pay for new maintenance contract for certain Akash Missile squadrons as the old ones expired in September 2019. They argued that missile systems in several squadrons were left idle for more than a year. Instead, it had asked for extension of warranty for certain squadrons which have been dysfunctional for 17 to 15 months in the last two years. Air Force asserted since system was down and faults were neither rectified nor replaced, it violated the maintenance contract. Air Force is learnt to have said that "during the warranty period, the seller shall either replace or rectify the failed goods free of charge within 30 days of notification of such defects. As per article of the contract, warranty of the equipment would be extended by such duration from time the buyer has reported such unserviceabilities till the time seller has restored the status of the buyer's satisfaction."
Red tapeism in government defence enterprises hurt national security
Firstpost investigation also revealed gross inefficiency of government defence agencies BEL, BDL and DRDL to address the problem in Akash Missile System. Documents reveal that meetings after meetings were convened on the issues but the government defence enterprises couldn't satisfactorily answer the questions raised by Air Force. These government defence enterprises have been passing the buck. They also cheated Air Force by providing substandard and fake spares.
A meeting earlier this year chaired by Air Vice Marshal Bhanoji Rao pointed at severe negligence in handling Akash Missile System which may have serious ramifications in contingency. Documents revealed that certain spares, especially those of sub-vendors (procured by BEL) were being received at Akash Missile System units without 'Quality Assurance' certification and on a few instances it came to light that these spares were old and fake. In a letter, it was noted: "On few instances it has been noticed that the items were not new/authentic."
Air Vice Marshal Rao clearly told his team at the Air Force not to accept spares without 'Quality Assurance' certification. The meeting also revealed a lack of expertise of government-owned defence enterprises which are acting merely as a supplier of equipment after procuring it from domestic and foreign vendors. It basically means that these government enterprises are acting like a payment facilitators. Their complicity in this entire saga was further exposed when government defence enterprises officials told the senior Air Force officials that sub-vendors (private companies supplying spares) were not willing to share their design documents.
An appalled Air Vice Marshal asked, if the Defence Research and Development Laboratory (DRDL) is the authority then it must have intellectual property rights of all designs related to Akash Missile System. Obviously, the defence agencies representatives were not aware about it since they never took the pain to look into the agreements and promised the Air Force to look into the matter to ascertain whether these rights were with vendors. A promise was made to list all major vendors for unhindered supply of spares to overcome single vendor situation. As far as BEL is concerned documents said: "Almost all squadrons have expressed that they are unable to get proper feedbacks from BEL on progress and plan of action of pending faults."
The meeting chaired by Air Vice Marshal Rao also discussed high failure rate of one of the systems of Akash Missile, lacunae in analysis of faults and mismatch in software versions used for the this strategic weapon.
Another major loophole, which highlights the non-seriousness of defence agencies, is the contract with the private vendors. The agreements are more favorable to private parties putting Akash Missile System in jeopardy. Documents flagged these concerns further pointing out that all the vendor supplied items are outside their warranty obligations and in certain cases supplied spares are not configured as per system requirements. Some spares for Akash Missiles are not fit and functional and this is affecting the equipment serviceability in case of failure.
It appears that careless handling of most critical weapons has been going on for a long time. The Comptroller and Auditor General of India (CAG) was perhaps far-sighted when in a 2017 report, the national auditor observed that Akash Missiles cannot be trusted in situation of a war. CAG had categorically stated that Akash missile system delivered by BEL were deficient in quality and 30% missiles failed the test.
"Audit found that the Strategic missile system delivered by BEL were deficient in quality. Out of 80 missiles received up to November 2014, 20 missiles were test fired during April-November 2014. Six of these missiles i.e., 30 percent, failed the test. Preliminary failure analysis report revealed that the missiles fell short of the target, had lower than the required velocity, and also there was malfunctioning of critical units like Servo Control Unit and Connector. Two missiles had failed to take off because the booster nozzle had failed. These deficiencies posed an operational risk during hostilities. Two missiles had failed to take off because the booster nozzle had failed. These deficiencies posed an operational risk during hostilities." CAG report had said.
Firstpost investigation showed that after the CAG report, the squabbling between government defence enterprises had come to light. Eight critical snags in Akash Missile Systems were reported after the CAG report which were pending for three-seven months. CAG had recommended that Ministry of Defence needs to ensure better synchronisation of the various activities and agencies involved in such strategically important projects to ensure their timely completion and quality of Strategic Missiles also needs improvement so as to bring down failure rate.
Notwithstanding, many snags were not rectified citing lack of spares. The Air Force anguished over lackadaisical attitude of BEL and BDL has firmly directed them to resolve all internal issues immediately and ensure that no Missile is kept unserviceable due to their internal problems.
Find latest and upcoming tech gadgets online on Tech2 Gadgets. Get technology news, gadgets reviews & ratings. Popular gadgets including laptop, tablet and mobile specifications, features, prices, comparison.
Updated Date: Dec 02, 2019 18:22:43 IST
https://www.firstpost.com/india/aka...ystem-threaten-national-security-7728651.html
